行业资讯
撒布车的相关保养方法
来源：https://www.sddhfjx.com/ 日期：2023-04-24
撒布车是路面建设养护常用的一种设备，它能够帮助我们快速铺设路面，确保路面的质量与效率，但是设备需要定时定期的保护，才可以确保车辆的正常运行。冷再生机租赁小编就为大家详细介绍撒布车保养方法
Spreader is a commonly used equipment for road construction and maintenance, which can help us quickly lay the road surface and ensure the quality and efficiency of the road surface. However, the equipment needs to be regularly protected to ensure the normal operation of the vehicle. The rental editor of the cold recycling machine will provide a detailed introduction to the maintenance methods of the spreader truck
1.车辆满载时，需要注意中速行驶，如果遇到弯道、下坡提前做好减速准备，尽量避免急刹，并且行驶时需要严禁加热。
When the vehicle is fully loaded, it is necessary to pay attention to driving at a medium speed. If encountering curves or downhills, prepare for deceleration in advance, try to avoid sudden braking, and strictly prohibit heating during driving.
2.检查车辆、洒布装置及防护、防火设备是否齐全有效，如果发现问题及时处理，避免引起危险；
2. Check whether the vehicle, spraying device, and protective and fire prevention equipment are complete and effective. If any problems are found, handle them promptly to avoid causing danger;
3.驾驶员与机上操作人员应密切配合，操作人员应注意自身的。作业时在喷洒沥青方向10m以内不得有人停留。
3. The driver and onboard operators should closely cooperate, and the operators should pay attention to their own safety. During operation, no one shall stay within 10m of the direction of spraying asphalt.
4.采用固定式喷灯向沥青箱的火管加热时，应先打开沥青箱上的烟囱口，并在液态沥青淹没火管后，方可点燃喷灯。
When using a fixed spray lamp to heat the fire pipe of the asphalt box, the chimney opening on the asphalt box should be opened first, and the spray lamp can only be ignited after the liquid asphalt submerges the fire pipe.
加热喷灯的火焰过大或扩散蔓延时应立即关闭喷灯，待多余的燃油烧尽后再行使用。喷灯使用前，应先封闭吸油管及进料口，手提喷灯点燃后不得接近易燃品。
When the flame of the heating burner is too large or spreads, the burner should be immediately turned off and used only after the excess fuel has burned out. Before using the blowtorch, the oil suction pipe and feeding port should be closed first. After igniting the portable blowtorch, it is not allowed to approach flammable materials.
平时使用的时候我们要注意以下几点：
When using it regularly, we should pay attention to the following points:
液压系统所使用的液压油为46#高清洁抗压耐磨液压油，补加的时候要特别注意，一定要把加油口处的粉尘清理干净，并适量补加，不要超过观察孔处的红色点位，以免液压油加多了产生外溢。如有外溢，请不要用水清洗，可选择擦拭清理的方式处理。
The hydraulic oil used in the hydraulic system is 46 # high clean, pressure resistant, and wear-resistant hydraulic oil. Special attention should be paid when adding it. The dust at the oil filling port must be cleaned and an appropriate amount should be added, not exceeding the red dot at the observation hole, to avoid overflow caused by adding too much hydraulic oil. If there is any overflow, please do not use water to clean it. You can choose to wipe and clean it.
因工作环境特殊，粉尘量较大，液压油箱的散热片会沾附较多粉尘，粉尘的沾附会影响液压油油温的下降并增加散热风扇的运转时间。因此，油箱散热片需要定期吹扫，吹扫的时候气枪不要离散热片过近，以免碰伤散热片。
Due to the special working environment and high dust content, the cooling fins of the hydraulic oil tank may be contaminated with a large amount of dust, which can affect the decrease in hydraulic oil temperature and increase the operating time of the cooling fan. Therefore, the fuel tank heat sink needs to be regularly purged, and the air gun should not be too close to the heat sink during purging to avoid damaging it.
液压油箱相关连接管件需要定期检查，查看有无松动现象，如有松动，及时复紧，以免产生液压油渗漏。
The relevant connecting fittings of the hydraulic oil tank need to be regularly inspected to see if there is any looseness. If there is looseness, it should be re tightened in a timely manner to avoid hydraulic oil leakage.
应特别注意，液压油箱散热风扇虽然会自动开启降温，但在使用过程中也会存在一定量的粉尘堆积，粉尘的堆积会影响散热片的散热效果，也会影响风扇的开启与关闭时间，影响着散热风扇的使用寿命。
Special attention should be paid to the fact that although the hydraulic oil tank cooling fan automatically starts to cool down, there may also be a certain amount of dust accumulation during use. The accumulation of dust can affect the heat dissipation effect of the cooling fins, as well as the opening and closing time of the fan, affecting the service life of the cooling fan.
撒布车的保养工作可以提高车辆的稳定性，让设备能够更好的运行，减少问题的发生，所以我们在使用中一定要注意这些问题，避免出现失误。更多相关内容就来我们网站http://www.sddhfjx.com咨询！
The maintenance work of the spreader can improve the stability of the vehicle, enable the equipment to operate better, and reduce the occurrence of problems. Therefore, we must pay attention to these issues during use to avoid errors. For more related content, come to our website http://www.sddhfjx.com consulting service
公司地址：济南市槐荫区经一路273号群盛华城2号楼1-404
公司名称：山东途畅路桥工程有限公司 
备案号：