1.土路肩滑模摊铺机滑模施工土路肩，实现机械化连续作业，成型的土路肩培土密实度高，土路肩棱角顺直，施工界面简洁、干净，提高施工效率。

　　1. The sliding mode paving machine for the construction of soil road shoulders achieves mechanized continuous operation. The formed soil road shoulders have high compaction and straight edges, and the construction interface is simple and clean, improving construction efficiency.

　　2.硬路肩滑模摊铺机硬路肩滑模机主要由液压气缸、自动系统、撞锤、专用硬路肩横具等4部分组成。采用该机生产可以使硬路肩直接成型浇注，并且可下嵌于土地基础，同时成型后的硬路肩具有较高的抗冲击强度和稳定性，其整体性强度及稳定性是远远优于传统方式生产的硬路肩，铺砌后的硬路肩顺直，线形流畅，硬路肩与路面标高均达到了设计要求且平整度好。

　　2. Hard shoulder sliding mode paver The hard shoulder sliding mode paver is mainly composed of four parts: hydraulic cylinder, automatic system, hammer, and dedicated hard shoulder crossbar. The use of this machine for production allows for direct molding and pouring of hard shoulders, which can be embedded in the soil foundation. At the same time, the formed hard shoulders have high impact resistance and stability, and their overall strength and stability are far superior to those produced by traditional methods. The paved hard shoulders are straight, with smooth lines, and the elevation of the hard shoulders and road surfaces meet the design requirements and have good flatness.

　　3.中分带填土喂料机填筑过程由摊铺机传送带运送土体至中央分隔带中，此过程只需人工配合清扫浮土。摊铺机传送带底部附带大粒径土块分筛装置，可以分离出大粒径填料，需要人工进行清除。回填完成后采用小型夯实机器跟进压实，直至满足设计压实度。对于未填筑到或超过设计标高的地方进行人工修整。回填施工机械化程度高，回填效率高，回填效果好，布料均匀，能够减少土体洒落，防止路面结构层污染效果显著。

　　3. The filling process of the filling feeder in the median strip is carried by the conveyor belt of the paver to transport the soil to the median strip, and this process only requires manual cooperation to clean the floating soil. The bottom of the conveyor belt of the paver is equipped with a large particle size soil block screening device, which can separate large particle size fillers and requires manual cleaning. After backfilling is completed, small compaction machines are used to follow up and compact until the design compaction degree is met. Manually repair areas that have not been filled to or exceed the design elevation. The mechanization level of backfilling construction is high, the backfilling efficiency is high, the backfilling effect is good, the fabric is uniform, and it can reduce soil scattering and prevent significant pollution of the pavement structure layer.

　　4.抗离析多功能全断面水稳摊铺机抗离析多功能全断面水稳摊铺机可实现水稳基层大宽度大厚度一机代替多机、一次成型摊铺避免了并机接缝造成的早期裂纹，接缝处离析，避免纵向接缝造成的不平整，双振捣夯实预压密实度高，削峰填谷找平效果好，提高了水稳层的平整度；履带液压自动张紧且履带加长设计，接地面积更大，行驶更加稳定，能保证施工过程的连续性，提高整体施工效率。

　　4. Anti segregation multifunctional full section water stable paver. The anti segregation multifunctional full section water stable paver can achieve a wide and thick water stable base layer with one machine instead of multiple machines, and one-time molding paving avoids early cracks caused by parallel machine joints, segregation at joints, and unevenness caused by longitudinal joints. The double vibration compaction pre compression density is high, the peak shaving and valley filling leveling effect is good, and the flatness of the water stable layer is improved; The track is designed with automatic hydraulic tensioning and elongated tracks, providing a larger grounding area and more stable driving, ensuring the continuity of the construction process and improving overall construction efficiency.

　　5.基层双层连铺工艺水稳基层双层连铺施工工艺是指在水稳下基层摊铺碾压成型后，立即通过侧向供料机摊铺碾压水稳上基层，两层连续摊铺后再进行覆盖养生，即“双层连铺、分层碾压、一次成型”。同时，半刚性基层采用双层连铺技术，其骨料最大可嵌入水稳下基层50%，由此可以形成较大的构造深度，上下基层集料咬合更佳，可有效提高层间的抗剪性能，使层间具有较好的整体性，且无明显层间分界线。

　　5. Double layer continuous paving process for base layer Water stable base layer Double layer continuous paving construction process refers to the process of immediately paving and rolling the water stable upper base layer through a lateral feeding machine after the water stable base layer is laid and compacted, and then covering and curing it after two consecutive layers of paving, that is, "double layer continuous paving, layered rolling, and one-time molding". At the same time, the semi-rigid base layer adopts double-layer continuous laying technology, and its aggregate can be embedded into up to 50% of the water stable lower base layer, thus forming a larger structural depth. The upper and lower base layers have better interlocking of aggregate, which can effectively improve the shear resistance between layers, make the layers have good integrity, and there is no obvious interlayer boundary line.

　　6.水泥净浆洒布车水泥净浆洒布车采用大功率搅拌、新型洒布装置，相较于传统靠人力完成水泥净浆洒布的方式，在提高施工速度的同时，能够保证施工效果，解决了传统施工中人力投入大、洒布效果差、安全隐患多等缺陷。水泥净浆洒布车

　　6. Cement slurry spraying truck adopts high-power mixing and a new type of spraying device. Compared with the traditional method of manually spraying cement slurry, it can improve the construction speed while ensuring the construction effect, solving the problems of large manpower input, poor spraying effect, and multiple safety hazards in traditional construction. Cement slurry spraying truck

　　7.水稳养生覆膜机全自动水稳覆膜机解决传统水稳养生人工覆盖土工布效率慢等问题，实现土工布自动覆盖养生，工人可手持遥控器自动启停开关，极大地提高了养生覆盖效率，确保底基层在终凝前能够及时保水养生，有效提升实体质量。

　　7. Water stable health laminating machine Fully automatic water stable laminating machine solves the problem of slow efficiency of traditional manual coverage of geotextile for water stable health preservation, realizing automatic coverage and health preservation of geotextile. Workers can hold a remote control to automatically start and stop the switch, greatly improving the health preservation coverage efficiency, ensuring that the subgrade can be timely water preserved and cured before final setting, effectively improving the quality of the entity.

　　8.水稳边部注浆机水稳摊铺层边部注浆机是一种控制浆液均匀性、注浆量的专用边部注浆设备，可降低施工成本、减少人员配置，提高施工效率，适宜于水泥稳定碎石基层铺设、改扩建道路及新旧水稳层结合部位应用，以提高基层边部、结合面密实度及强度，保证施工质量。

　　8. Water stable edge grouting machine Water stable paving layer edge grouting machine is a specialized edge grouting equipment that controls the uniformity and grouting volume of the slurry. It can reduce construction costs, personnel configuration, and improve construction efficiency. It is suitable for the laying of cement stabilized crushed stone base, the expansion and reconstruction of roads, and the application of new and old water stable layer joints to improve the compactness and strength of the base edge and joint surface, and ensure construction quality.

　　9.同步碎石封层撒布车智能控制沥青和碎石洒布量，洒布精度高，喷洒过程由计算机全程控制，同一点的沥青和碎石撒到地面的时间间隔不超过0.5秒，极大效果增加沥青与碎石的黏结度，最大程度的提高了路面的质量。

　　9. The synchronous gravel sealing layer spreading vehicle intelligently controls the amount of asphalt and gravel sprayed, with high spraying accuracy. The spraying process is fully controlled by the computer, and the time interval for asphalt and gravel to be sprayed on the ground at the same point does not exceed 0.5 seconds, greatly increasing the adhesion between asphalt and gravel and improving the quality of the road surface to the maximum extent.

　　10. 抗离析多功能摊铺机抗离析摊铺机的核心原理为采用封闭搅拌槽，使得物料满埋轮旋，同时强制挤推可进行二次搅拌。有效改善前道工序（装卸、运输等）离析问题；减少结核状离析；避免并机接缝离析；实现了路面摊铺的高均匀度、高密实度、高平整度；实现了单机大宽度、大厚度、大粒径、动态大幅变宽抗离析摊铺作业，实现了沥青和水稳的多用途摊铺，大大提高了施工效率。

　　10. Anti segregation multifunctional paver The core principle of the anti segregation paver is to use a closed mixing tank, so that the material is fully buried and the wheel rotates, and at the same time, forced squeezing can be used for secondary mixing. Effectively improve the segregation problem in the previous process (loading and unloading, transportation, etc.); Reduce tuberculosis like segregation; Avoid segregation of parallel machine seams; Achieved high uniformity, high density, and high flatness in road paving; It has achieved single machine wide, thick, large particle size, dynamic and greatly variable width anti segregation paving operation, realizing multi-purpose paving of asphalt and water stability, greatly improving construction efficiency.

　　11. 3D智能摊铺、碾压成套设备施工现场的路面成套摊铺压实设备通过平台全自动化监控机群设备的施工工况。通过施工现场的大屏幕，可清晰地看到设备在施工过程中的运行轨迹、下料数据、生产下单等多维度数据。智能压实辅助系统是基于高精度北斗定位、智能传感器、无线网络、云平台、大数据而开发的新一代数字智能化施工辅助系统，该系统改变了传统摊铺压实作业的缺点，还可以对行车速度与压实温度进行语音提示，避免车速太快、温度太低影响施工效果。同时，系统可以完整记录每一次碾压过程，提高施工质量和效率，降低施工测量难度和提升施工数据采集效率。

　　11. The complete set of 3D intelligent paving and compaction equipment is used to monitor the construction conditions of the road surface paving and compaction equipment on the construction site through a fully automated platform. Through the large screen on the construction site, multi-dimensional data such as the operation trajectory, cutting data, and production orders of the equipment during the construction process can be clearly seen. The intelligent compaction assistance system is a new generation of digital intelligent construction assistance system developed based on high-precision Beidou positioning, intelligent sensors, wireless networks, cloud platforms, and big data. This system changes the shortcomings of traditional paving and compaction operations and can also provide voice prompts for driving speed and compaction temperature, avoiding the impact of too fast speed and too low temperature on construction results. At the same time, the system can fully record every compaction process, improve construction quality and efficiency, reduce construction measurement difficulty, and enhance construction data collection efficiency.

　　12. 自动揭盖篷布沥青运输车运输车轨道式自动篷布通过遥控电机带动篷布转动装置，使U 型钢管支撑的篷布沿固定钢缆平行滑动，最后由篷布转向档杆和转向挡柱配合完成车斗尾端混合料的覆盖。在实际使用中较传统篷布覆盖率更高，可操控性强，有效的降低了运输过程中造成的扬尘污染。

　　12. Automatic uncovered tarpaulin asphalt transport vehicle track type automatic tarpaulin is driven by a remote control motor to rotate the tarpaulin device, allowing the U-shaped steel pipe supported tarpaulin to slide parallel to the fixed steel cable. Finally, the tarpaulin steering gear lever and steering gear column cooperate to complete the coverage of the mixture at the tail end of the vehicle bucket. In practical use, it has a higher coverage rate and stronger controllability compared to traditional tarpaulins, effectively reducing dust pollution caused during transportation.

　　13. 沥青保温运输车沥青保温运输车具有沥青自流卸出、泵压卸出、泵吸装罐、原地输送等功能；沥青罐设有加热系统，配备进口柴油燃烧器，燃烧质量好，无污染。采用独特的导热油系统对沥青泵、阀加热保温，液压系统驱动沥青泵和导热油泵，传动可靠，操作方便。

　　13. Asphalt insulation transport vehicles have functions such as self flow unloading of asphalt, pump pressure unloading, pump suction tank loading, and on-site transportation; The asphalt tank is equipped with a heating system and imported diesel burners, which have good combustion quality and no pollution. Adopting a unique thermal oil system to heat and insulate the asphalt pump and valve, the hydraulic system drives the asphalt pump and thermal oil pump, ensuring reliable transmission and easy operation.

　　14. 沥青透层洒布车沥青透层洒布车配备了先进的控制系统，能够根据输入的洒布量和喷洒宽度及沥青种类，自动计算沥青泵转数，从而实现精确的洒布。这种精确控制有助于确保施工质量，减少浪费

　　14. Asphalt prime coat spraying truck is equipped with an advanced control system that can automatically calculate the speed of the asphalt pump based on the input spraying amount, spraying width, and asphalt type, thereby achieving accurate spraying. This precise control helps ensure construction quality and reduce waste

　　16.取芯防污染器取芯防污染器可防止水流四溢，减少了因水流溢出导致的清理和重复工作，提高了工作效率，并且结构简单，适用性强。无论是小型手持式还是大型坐立式取样机都能适应。

　　16. Core taking anti pollution device The core taking anti pollution device can prevent water overflow, reduce cleaning and repetitive work caused by water overflow, improve work efficiency, and has a simple structure and strong applicability. Both small handheld and large seated sampling machines can adapt.

　　17.碾压设备预警防撞系统在设备前后安装防碰撞感知设备，防碰撞感知设备在触碰障碍物的瞬间，感知装置接收信号，信号传递到碰撞危险判断单元，判断单元对危险程度进行判断识别，进而将判断信息传递至刹车系统、驾驶室警示装置进行执行，刹车并警示压路机驾驶员前方发生碰撞。有效提高路面工程施工安全性能，增强对施工作业人员的安全防护。

　　17. The early warning and collision avoidance system for rolling equipment is equipped with collision avoidance perception devices in front and behind the equipment. When the collision avoidance perception device touches an obstacle, the perception device receives a signal, which is transmitted to the collision danger judgment unit. The judgment unit judges and recognizes the degree of danger, and then transmits the judgment information to the braking system and the driver's cab warning device for execution, braking and warning the roller driver of a collision ahead. Effectively improve the safety performance of road construction and enhance the safety protection of construction workers.

　　本文由  水泥撒布车出租  友情奉献.更多有关的知识请点击  https://www.sddhfjx.com/   真诚的态度.为您提供为全面的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

　　This article is a friendly contribution from a cement spreader rental For more related knowledge, please click https://www.sddhfjx.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.