清洗频率建议

　　Suggested cleaning frequency

　　常规使用情况下，建议每使用1–2天就对水泥净浆洒布车进行一次清洗，避免水泥浆在罐体、管路和喷嘴内结块硬化，影响流量与喷洒均匀性，并降低泵与密封件的磨损与堵塞风险。

　　Under normal usage, it is recommended to clean the cement slurry distribution truck every 1-2 days to prevent cement slurry from clumping and hardening in the tank, pipelines, and nozzles, affecting flow and spray uniformity, and reducing the risk of pump and seal wear and blockage.

　　必须立即清洗的情形

　　Situations that require immediate cleaning

　　更换施工工地或喷洒材料批次后（防止不同配比或材料交叉污染）。

　　After changing the construction site or spraying material batch (to prevent cross contamination of different proportions or materials).

　　单次作业后罐内仍有残留或喷嘴出现滴漏、雾化不均时（趁未干结及时冲洗）。

　　When there are still residues in the tank or when there is dripping or uneven atomization from the nozzle after a single operation (rinse promptly before it dries).

　　发现管路或泵体有异响、振动、流量明显下降等异常征兆时（先清洗排查，必要时检修）。

　　When abnormal signs such as abnormal noise, vibration, and significant decrease in flow rate are found in the pipeline or pump body (clean and investigate first, and repair if necessary).

　　遇雨雪或低温天气前（防止残留浆体受冻膨胀损伤罐体与管路）。

　　Before encountering rain, snow or low temperature weather (to prevent residual slurry from freezing, expanding and damaging the tank and pipelines).

　　清洗要点与维护提示

　　Cleaning points and maintenance tips

　　作业结束后应尽快用清水将罐体、管网与喷嘴冲洗干净，必要时配合适量清洗剂；清洗后将残留水分排净并擦干关键部位，减少锈蚀与结垢。

　　After the homework is completed, the tank, pipe network, and nozzle should be rinsed clean with clean water as soon as possible, and an appropriate amount of cleaning agent should be used if necessary; After cleaning, remove any residual moisture and dry key areas to reduce rust and scaling.

　　冬季停驶或低温环境前，务必将水泵与管路内的水彻底放空，防止冻裂；长期停用也应排空并做防锈处理。

　　Before stopping operation in winter or in low-temperature environments, it is necessary to completely drain the water pump and pipeline to prevent freezing and cracking; Long term disuse should also be emptied and treated with rust prevention.

　　按设备使用手册定期检查泵油（或润滑脂）、密封件与阀门状态，保持良好润滑与密封，延长使用寿命。

　　Regularly check the pump oil (or grease), seals, and valve status according to the equipment manual to maintain good lubrication and sealing, and extend the service life.

　　本文由 水泥撒布车出租 友情奉献.更多有关的知识请点击  https://www.sddhfjx.com/   真诚的态度.为您提供为全面的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

　　This article is a friendly contribution from a cement spreader rental For more related knowledge, please click https://www.sddhfjx.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.