水泥撒布车在道路工程建设中发挥着重要的作用，和以往的人力施工相比更环保、更高效、更节能，所以得到广泛应用。众所周知，对车辆进行定期维护保养有利于延长设备的使用寿命，那么水泥撒布车的维护保养要点您了解多少呢？

　　Cement spreading vehicles play an important role in road engineering construction, and are more environmentally friendly, efficient, and energy-saving compared to traditional manual construction, so they are widely used. As is well known, regular maintenance of vehicles is beneficial for extending the service life of equipment. So, how much do you know about the maintenance points of cement spreading vehicles?

　　下面，小编为大家整理了一些水泥撒布车的维护保养小知识，一起来了解相关内容吧。

　　Below, the editor has compiled some maintenance tips for cement spreading trucks. Let's learn about the relevant content together.

　　空滤的作用

　　The function of air filtration

　　在车辆的千千万万个零部件中，空气滤清器是一个极不起眼的部件，因为它不直接关系到汽车的技术性能，但在车辆的实际使用中，空气滤清器却对车辆（特别是发动机）的使用寿命有极大的影响。一方面，如果没有空气滤清器的过滤作用，发动机会吸入大量含有尘埃、颗粒的空气，导致发动机气缸磨损严重；另一方面，如果在使用过程中，长时间不进行维护保养，空气滤清器的滤芯就会沾满空气中的灰尘，这不但使过滤能力下降，而且还会妨碍空气的流通，导致混合气过浓而使发动机工作不正常。因此，按期维护保养空气滤清器是至关重要的。

　　Among the countless components of a vehicle, the air filter is a very inconspicuous part because it is not directly related to the technical performance of the car. However, in actual use of the vehicle, the air filter has a great impact on the service life of the vehicle (especially the engine). On the one hand, without the filtering effect of an air filter, the engine will inhale a large amount of air containing dust and particles, resulting in severe cylinder wear; On the other hand, if maintenance is not carried out for a long time during use, the filter element of the air filter will be covered with dust in the air, which not only reduces the filtering ability, but also hinders the circulation of air, resulting in excessive mixture and abnormal engine operation. Therefore, regular maintenance of the air filter is crucial.

　　干过滤式滤清的保养：干过式空气滤清装置由纸质滤芯及密封垫圈等组成，使用中应注意

　　Maintenance of dry filtration: The dry filtration air filtration device consists of a paper filter element and a sealing gasket. Attention should be paid during use

　　1、定期检查，正确保洁。清除纸滤芯上的灰尘时，应用软毛刷沿时，应用软毛刷沿折缝方向刷去滤芯表面灰尘土，并轻轻敲击端面使尘土脱落。进行上述操作时，应用干净的棉布或橡皮塞堵住滤芯两端，以压缩空气机或打气筒（气压不得超过 0.2-0.3MPA，以防损坏滤纸）从滤芯内向外吹气，以吹去粘附在滤芯外表面上的灰尘。

　　1. Regular inspections and proper cleaning. When removing dust from the paper filter element, use a soft bristled brush to brush away the dust and dirt on the surface of the filter element along the crease direction, and gently tap the end face to remove the dust. When performing the above operation, use a clean cotton cloth or rubber stopper to block both ends of the filter element, and use a compressed air machine or an air pump (with a pressure not exceeding 0.2-0.3MPA to prevent damage to the filter paper) to blow air from inside the filter element to the outside to remove dust adhering to the outer surface of the filter element.

　　2、不要用水或柴油、汽油清洗纸质滤芯，否则滤芯孔隙被堵塞，增加空气阻；同时柴油易吸入气缸，造成裝后超支“飞车”。

　　2. Do not clean the paper filter element with water, diesel, or gasoline, otherwise the pores of the filter element will be blocked, increasing air resistance; At the same time, diesel is easily drawn into the cylinder, causing overspending and "flying" after installation.

　　3、当发现滤芯破损，或滤芯上、下端面翘不平，或橡胶密封圈老化变形、破损，均应更换新件。

　　3. When the filter element is found to be damaged, or the upper and lower ends of the filter element are uneven, or the rubber sealing ring is aged, deformed, or damaged, new parts should be replaced.

　　4、安装时，要注意各结合部件的垫片或密封圈不得漏装或错裝，以免空气短路。滤芯蝶形螺母不要拧得过紧，以防压坏滤芯。

　　4. During installation, it is important to ensure that the gaskets or sealing rings of each joint component are not missing or incorrectly installed to prevent air short circuits. Do not tighten the butterfly nut of the filter element too tightly to prevent damage to the filter element.

　　通过我们的一番介绍，相信大家对水泥撒布车的维护保养要点有了相应的了解，只有按照正确的维护保养方法，才能延长机器的使用寿命，提高设备的工作效率。

　　Through our introduction, we believe that everyone has gained a corresponding understanding of the maintenance points of cement spreader trucks. Only by following the correct maintenance methods can the service life of the machine be extended and the work efficiency of the equipment be improved.

　　本文由  水泥撒布车 友情奉献.更多有关的知识请点击  https://www.sddhfjx.com/   真诚的态度.为您提供为全面的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

　　This article is a friendly contribution from a cement spreader truck For more related knowledge, please click https://www.sddhfjx.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.