公司新闻
沥青摊铺机租赁的施工分析
来源：https://www.sddhfjx.com/ 日期：2021-08-19
了提高润滑油的润滑性能，会添加一些添加剂，但使用后很快就会变黑。我们不能认为油已经变质了，可以轻易更换。在判断润滑油是否变质时，应进行综合分析。
In order to improve the lubricating performance of lubricating oil, some additives will be added, but it will turn black soon after use. We can't think that the oil has gone bad and can be replaced easily. Comprehensive analysis shall be conducted when judging whether the lubricating oil has deteriorated.
摊铺机操作说明书规定的油品等级适用于一般工况。在换油和维护过程中，还应考虑实际操作条件。如果实际操作条件比规定条件苛刻，应选择好油品。
The oil grade specified in the paver operation manual is applicable to general working conditions. Actual operating conditions shall also be considered during oil change and maintenance. If the actual operating conditions are more severe than the specified conditions, the oil shall be selected.
摊铺机中少量的油会导致供油不足和润滑不良。因此，由于担心石油不足，没有必要增加更多的石油。过量的润滑油不仅会由于旋转阻力的增加而增加曲轴的功耗，而且容易导致润滑不良。
A small amount of oil in the paver will lead to insufficient oil supply and poor lubrication. Therefore, there is no need to add more oil due to the fear of oil shortage. Excessive lubricating oil will not only increase the power consumption of the crankshaft due to the increase of rotating resistance, but also easily lead to poor lubrication.
1、如果使用新的摊铺机，我们建议我们应该注意设备的磨合情况，它有磨合期。如果不注意设备的磨合，就会加速设备部件的磨损。
1. If a new paver is used, we suggest that we should pay attention to the running in of the equipment, which has a running in period. If you do not pay attention to the running in of the equipment, it will accelerate the wear of equipment components.
2、摊铺机上的空气过滤元件和摊铺机的租约都建议我们及时清理或更新。所用的油也应该及时更换。使用不合格的机油也会影响设备的发动机。
2. The air filter elements on the paver and the lease of the paver suggest that we clean or update them in time. The oil used should also be replaced in time. The use of unqualified engine oil will also affect the engine of the equipment.
3、平时使用沥青摊铺机租赁时，应注意检查设备，有无异常噪音，操作中有无打滑现象，并及时观察设备系统是否过热。
3. When using the asphalt paver for lease at ordinary times, pay attention to check the equipment for abnormal noise and slip during operation, and timely observe whether the equipment system is overheated.
沥青摊铺机租赁
Asphalt paver leasing
在进行地面施工时，沥青摊铺机的使用率很高。它不仅效果好，而且平面度误差小。如果混凝土沥青摊铺机在磨损机上，维护保养的是什么？
During ground construction, the utilization rate of asphalt paver is very high. It not only has good effect, but also has small flatness error. If the concrete asphalt paver is on the wear machine, what is the focus of maintenance?
1、沥青摊铺机的操作人员应接受制造商的培训和领导，对机器的结构和性能有足够的了解，并具备操作机器所必需的操作和维护经验。
1. The operators of the asphalt paver shall receive the training and leadership of the manufacturer, have a sufficient understanding of the structure and performance of the machine, and have the necessary operation and maintenance experience to operate the machine.
2、试运转期间应注意工作量。磨合期的工作量不应超过额定工作量的80%。应配置适当的工作负荷，以防止机器长期连续运行导致过热。
2. Pay attention to the workload during commissioning. The workload during the running in period shall not exceed 80% of the rated workload. Appropriate working load shall be configured to prevent overheating caused by long-term continuous operation of the machine.
3、应注意经常检查各仪表的情况，发现异常情况，及时停车排除，排除故障前应停止操作。
3. Pay attention to check the condition of each instrument frequently. If abnormal conditions are found, stop the machine in time for troubleshooting. Stop the operation before troubleshooting.
4、注意检查混凝土激光摊铺机的润滑油、液压油、制动液和燃油油位，检查摊铺机的密封情况。检查中发现油、水过多，应分析原因。
4. Pay attention to check the lubricating oil, hydraulic oil, brake fluid and fuel level of the concrete laser paver, and check the sealing of the paver. If too much oil and water are found during the inspection, the cause shall be analyzed.
5、保持摊铺机清洁，及时调整和拧紧松动件，防止松动件磨损或丢失。
5. Keep the paver clean, adjust and tighten the loose parts in time to prevent the loose parts from being worn or lost.
公司地址：济南市槐荫区经一路273号群盛华城2号楼1-404
公司名称：山东途畅路桥工程有限公司 
备案号：